Common problems

Citroen C-Crosser common problems

What MOT testers find on the Citroen C-Crosser: the parts that fail or get advisories most often at each age, against all cars of the same age. From 6,100 DVSA MOT tests taken 2022 to 2025.

MOT data updated 28 September 2026

At 15 years, the most tested age

Suspension fails per 100 MOTs (n=1,879)22.9

All cars at 15 years (n=5,591,675)16.7

Suspension advisories and minor defects per 100 MOTs (n=1,879)46.1

All cars, same age (n=5,591,675)32.3

What stands out

Steering fails show up on 10.8 of every 100 MOTs of a Citroen C-Crosser at 15 years old (n=1,879), against 3.3 for all cars of that age (n=5,591,675).
Body and structure fails are less common: 4.0 per 100 MOTs against 6.7 for all cars at the same age.
The fail item testers record most often at 15 years: steering track rod end: ball joint play, on 9.0 per 100 MOTs (all cars 1.9).
The most common advisory or minor defect: rigid brake pipes: corroded, covered in grease or other material, on 23.6 per 100 MOTs.

Problems by part at 15 years

How many of every 100 MOTs found a fail, or an advisory or minor defect, in each area. A test with faults in two areas counts in both.

Citroen C-Crosser at 15 years (n=1,879) against all cars at 15 years (n=5,591,675). Per 100 MOTs.
Area	Fails	All cars	Advisories	All cars
Suspension	22.9	16.7	46.1	32.3
Lights and electrics	19.8	19.5	17.5	13.7
Brakes	15.2	10.7	42.7	27.8
Steering	10.8	3.3	7.0	4.3
Windscreen, wipers and mirrors	7.0	6.5	6.2	5.4
Tyres	6.4	7.5	28.5	28.5
Exhaust, emissions and leaks	4.4	5.7	16.2	11.0
Body and structure	4.0	6.7	8.5	11.2
Seat belts and airbags	0.8	1.7	0.7	1.0
Road wheels	0.5	0.6
Number plates and VIN	0.3	0.5	2.3	4.3

What testers fail most on the C-Crosser at 15 years

Fail items on the Citroen C-Crosser at 15 years (n=1,879), per 100 MOTs, with all cars at the same age (n=5,591,675).
Item	Area	Per 100 MOTs	All cars	Typical repair (estimate)
Steering track rod end: ball joint play	Steering	9.0	1.9	£54 to £128 per side (rough guide)
Side/position light not working	Lights and electrics	9.0	5.8	£10 to £47 per lamp
Suspension ball joint worn	Suspension	7.1	2.5	£75 to £237 per side (rough guide)
Anti-roll bar link worn	Suspension	4.4	1.5	£33 to £102 per link (rough guide)
Rigid brake pipes: excessively corroded	Brakes	3.9	1.3	£137 to £392 per car (rough guide)
Tyre tread below 1.6 mm	Tyres	3.6	3.1	£88 to £145 per tyre
Headlamp aim: projected beam image is obviously incorrect	Lights and electrics	3.0	2.5	£16 to £39 per car (rough guide)
Registration plate lamp(s): inoperative in the case of a single lamp or all lamps	Lights and electrics	3.0	2.0	£10 to £47 per lamp
Linkage ball joint dust cover: ball joint dust cover no longer prevents the ingress of dirt	Suspension	3.0	1.7	£33 to £102 per link (rough guide)
Brake pads under 1.5 mm	Brakes	2.9	2.0	£72 to £174 per axle (rough guide)

Early warnings: advisories and minor defects at 15 years

Advisories and minor defects are recorded, but the car still passes. Across all cars, a part with an advisory or minor defect failed at the next MOT 5.5 times in 100 (n=88,666,940 pairs of consecutive MOTs), against 0.3 times in 100 when the same part had none (n=12,936,860,350).

Advisories and minor defects on the Citroen C-Crosser at 15 years (n=1,879), per 100 MOTs, with all cars at the same age (n=5,591,675).
Item	Area	Per 100 MOTs	All cars	If it needs replacing (estimate)
Rigid brake pipes: corroded, covered in grease or other material	Brakes	23.6	7.2	£137 to £392 per car (rough guide)
Tread depth: worn close to legal limit/worn on edge	Tyres	21.4	18.4	£88 to £145 per tyre
Brake discs: worn, pitted or scored, but not seriously weakened	Brakes	16.2	11.1	£148 to £376 per axle (rough guide)
Engine oil leaks: leak, but not excessive	Exhaust, emissions and leaks	14.7	9.8
Sub-frame: corroded but not seriously weakened	Suspension	13.8	5.0
Suspension arm: corroded but not seriously weakened	Suspension	9.7	2.6	£92 to £237 per arm (rough guide)
Registration plate lamp(s): inoperative in the case of multiple lamps or light sources	Lights and electrics	9.4	5.9
Brake pads: wearing thin	Brakes	9.1	6.9	£72 to £174 per axle (rough guide)
Coil spring: corroded	Suspension	9.1	7.0
Suspension arm pins and bushes: pin or bush worn but not resulting in excessive movement	Suspension	8.9	8.5	£92 to £237 per arm (rough guide)

Repair estimates are a guide for an independent garage: labour at the national median local garage rate (median £78 an hour from 65 garages, ONS price quotes) times estimated labour hours, plus a parts band. Labour hours and most parts bands are estimates, not quotes, and prices vary by model, engine and region. A warning light fault shows the cost of the diagnosis only.

How problems change with age

Fails per 100 MOTs in the three most common areas at 15 years. Ages with fewer than 1,000 tests are not shown.
Age	Tests (n)	Suspension	Lights and electrics	Brakes
13 years	1,156	17.4	16.7	13.3
14 years	1,836	20.3	17.0	12.7
15 years	1,879	22.9	19.8	15.2
16 years	1,229	23.2	21.6	15.5

What to check on a viewing

On the Citroen C-Crosser, testers most often record steering track rod end: ball joint play; side/position light not working; suspension ball joint worn. Look at these first, then the areas below.

Suspension

Listen for knocks or clonks over speed bumps and rough roads on the test drive.
Push down hard on each corner: the car should settle at once rather than keep bouncing.
Look behind the wheels for broken or heavily rusted coil springs and split rubber bushes.
Check that the car sits level and that no tyre is worn on one edge only.

Lights and electrics

With someone outside, try every light: dipped and main beam, indicators, brake lights, fog lights and number plate lamps.
Check that the warning lights come on with the ignition and go out once the engine runs.
Look for misted, cracked or yellowed headlamp lenses.

Brakes

On the test drive the car should stop in a straight line without pulling, juddering or grinding.
Look at the discs through the wheels for a deep lip, heavy rust or scoring.
Check that the handbrake or electronic parking brake holds the car on a slope.
Ask when the pads, discs and brake fluid were last changed, and for the receipts.

Ask for the car's MOT history and service record: advisories that repeat from one year to the next show what has been left. GOV.UK MOT history.

Questions

What are the most common problems on the Citroen C-Crosser?

At 15 years, the age with the most MOT tests (1,879), the fail items testers record most often on the Citroen C-Crosser are steering track rod end: ball joint play (9.0 per 100 MOTs), side/position light not working (9.0 per 100 MOTs), suspension ball joint worn (7.1 per 100 MOTs). The most common advisories or minor defects are rigid brake pipes: corroded, covered in grease or other material (23.6) and tread depth: worn close to legal limit/worn on edge (21.4).

Which parts of the Citroen C-Crosser fail more often than on other cars?

At 15 years: steering (10.8 per 100 MOTs against 3.3 for all cars); suspension (22.9 per 100 MOTs against 16.7 for all cars); brakes (15.2 per 100 MOTs against 10.7 for all cars). Compared with 5,591,675 MOTs of all cars the same age.

Citroen C-Crosser problems by area

Other Citroen models

All Citroen models · Common problems by make

Read this with care. A fail rate is not a measure of build quality. How far cars are driven, how they are used and how well owners maintain them all change it, and wear items such as tyres and brake pads are common fails. Compare a model only with cars of the same age. Methodology and limits.

The all cars figures cover all class 4 vehicles (cars and light vans) tested at the same age.

Looking at a Citroen C-Crosser?

These figures describe the model, not the car in front of you. Found one you might buy? See what the VetTheCar Buying Report covers, or use the tools that work without a registration.

See a sample report Car tools · MOT fail rates by model · Compare models by MOT record

Repair estimates: ONS consumer price quotes for local garage labour (09/2025 to 08/2026), the MOT inspection manual for defect wording, and estimated labour hours and parts bands. Not affiliated with or endorsed by ONS.

Source

Contains public sector information licensed under the Open Government Licence v3.0. Source: DVSA anonymised MOT test data, class 4 normal MOT tests, 2022 to 2025. MOT data updated 28 September 2026.

Not affiliated with or endorsed by DVSA. How we calculate these figures · Data sources