MOT fail rates by first-use year
2005 Peugeot Expert MOT fail rate and common faults
How Peugeot Expert cars first used in 2005 did at their MOTs from 2022 to 2023, against all cars of the same age. From 2,815 DVSA MOT tests of these cars. First use is usually the date the car was first registered.
MOT data updated
At 18 years, tested in 2023
What stands out
- In 2023, at 18 years old, Peugeot Expert cars first used in 2005 failed 51.6% of MOTs (1,232 tests), 8.4 points above the 43.3% for all cars that age.
- From 2022 to 2023, as these cars went from 17 to 18 years old, the fail rate moved from 53.1% to 51.6%.
- The most common fail item that is not a wear item, for the Peugeot Expert at 18 years, is component mounting prescribed areas: prescribed area excessively corroded significantly reducing structural strength, at 9.9 per 100 MOTs (all cars: 2.3).
MOT fail rate by test year
| Test year | Age | MOT fail rate | Tests (n) | All cars | Difference |
|---|---|---|---|---|---|
| 2022 | 17 years | 53.1% | 1,583 | 43.1% | +10.0 pts |
| 2023 | 18 years | 51.6% | 1,232 | 43.3% | +8.4 pts |
Most common faults at 18 years
These figures cover all Peugeot Expert MOTs at 18 years: cars first used 2004 to 2007, tested 2022 to 2025 (n=5,148). The list uses every first-use year so it has enough tests. Wear items (tyres, brake pads, wipers, bulbs) say more about upkeep than about the design.
MOT fail items
| Fail item | Per 100 MOTs | All cars |
|---|---|---|
| Component mounting prescribed areas: prescribed area excessively corroded significantly reducing structural strength | 9.9 | 2.3 |
| Driveshaft CV boot split | 9.1 | 3.2 |
| Side/position light not working Wear | 7.8 | 5.6 |
| Suspension ball joint worn | 5.7 | 2.4 |
| Wipers not clearing screen Wear | 5.0 | 3.0 |
| Brake light not working Wear | 4.4 | 4.0 |
| Tyre tread below 1.6 mm Wear | 3.6 | 2.9 |
| Exhaust system: has a major leak of exhaust gases | 3.5 | 2.0 |
| Headlamp aim: projected beam image is obviously incorrect Wear | 3.2 | 4.0 |
| Integral vehicle structure condition: corroded to the extent that the rigidity of the assembly is significantly reduced | 3.1 | 0.6 |
Per 100 of the MOTs above (n=5,148). A test with two items counts once for each.
Advisories
| Advisory | Per 100 MOTs | All cars |
|---|---|---|
| Engine oil leaks: leak, but not excessive | 28.0 | 12.6 |
| Tyre tread close to the legal limit or worn on the edge Wear | 18.0 | 17.4 |
| Drive shaft joints: constant velocity boot severely deteriorated | 11.9 | 4.0 |
| Rigid brake pipes: corroded, covered in grease or other material | 10.1 | 12.3 |
| Tyre condition: slightly damaged/cracking or perishing Wear | 9.9 | 9.8 |
| Brake discs: worn, pitted or scored, but not seriously weakened | 9.5 | 11.1 |
| Registration plate lamp(s): inoperative in the case of multiple lamps or light sources Wear | 9.3 | 5.8 |
| Coil spring: corroded | 8.5 | 7.7 |
| Component mounting prescribed areas: prescribed area is corroded but not considered excessive | 7.2 | 2.8 |
| Exhaust system: has a minor leak of exhaust gases | 6.9 | 5.0 |
Per 100 of the MOTs above (n=5,148). A test with two items counts once for each.
Fuel type at 18 years
These figures cover all Peugeot Expert MOTs at 18 years: cars first used 2004 to 2007, tested 2022 to 2025 (n=5,148). Each fuel is set against all cars of the same fuel and age. Fuels with fewer than 1,000 tests are not shown.
| Fuel | Share of tests | MOT fail rate | Tests (n) | All cars, same fuel | Median mileage |
|---|---|---|---|---|---|
| Diesel | 100.0% | 50.6% | 5,143 | 43.6% | 129,837 miles |
Car tax rules for a 2005 car
- Cars first registered from 1 March 2001 to 31 March 2017 are taxed by CO2 emissions band, from band A (the lowest emissions) to band M. The band is set by the CO2 figure on the V5C logbook.
These are the rules, not the amount for a specific car. Car tax check
ULEZ and clean air zones
- Diesel cars first registered before September 2015 usually do not meet Euro 6, so a 2005 diesel usually pays the ULEZ daily charge. A few models met Euro 6 early.
- The clean air zones in Birmingham and Bristol use the same Euro 4 petrol and Euro 6 diesel standards. The low emission zones in Scotland use them too, but enforce them with fines, not a daily charge.
The Euro standard of the car decides, not the year alone. ULEZ checker
Other years of the Peugeot Expert
Other Peugeot models first used in 2005
| Model | Age at test | MOT fail rate | Tests (n) | All cars |
|---|---|---|---|---|
| Peugeot 206 (2005) | 20 years in 2025 | 44.9% | 6,669 | 42.8% |
| Peugeot 307 (2005) | 20 years in 2025 | 51.8% | 3,393 | 42.8% |
| Peugeot Boxer (2005) | 20 years in 2025 | 35.9% | 2,434 | 42.8% |
| Peugeot 107 (2005) | 20 years in 2025 | 46.9% | 1,688 | 42.8% |
| Peugeot 407 (2005) | 19 years in 2024 | 48.2% | 1,163 | 43.2% |
More on the Peugeot Expert
Found one you might buy? Vet the specific car.
These figures describe 2005 Peugeot Expert cars as a group, not any one car. The VetTheCar Buying Report looks at the car you are buying: its MOT history, what similar cars did next, and what to ask the seller.
Source
Contains public sector information licensed under the Open Government Licence v3.0. Source: DVSA anonymised MOT test data, class 4 normal MOT tests, 2022 to 2025. MOT data updated 28 September 2026.
Not affiliated with or endorsed by DVSA. How we calculate these figures · Data sources
Car tax and clean air zone rules are summarised from GOV.UK and Transport for London guidance. They are general rules and are not drawn from the MOT data.