Common problems

Toyota Auris common problems

What MOT testers find on the Toyota Auris: the parts that fail or get advisories most often at each age, against all cars of the same age. From 623,950 DVSA MOT tests taken 2022 to 2025.

MOT data updated 28 September 2026

At 8 years, the most tested age

Lights and electrics fails per 100 MOTs (n=65,525)9.5

All cars at 8 years (n=10,440,457)7.3

Tyres advisories and minor defects per 100 MOTs (n=65,525)20.5

All cars, same age (n=10,440,457)25.2

What stands out

Lights and electrics fails show up on 9.5 of every 100 MOTs of a Toyota Auris at 8 years old (n=65,525), against 7.3 for all cars of that age (n=10,440,457).
Suspension fails are less common: 3.2 per 100 MOTs against 6.1 for all cars at the same age.
The fail item testers record most often at 8 years: brake light not working, on 3.0 per 100 MOTs (all cars 1.3).
The most common advisory or minor defect: tread depth: worn close to legal limit/worn on edge, on 11.8 per 100 MOTs.

Problems by part at 8 years

How many of every 100 MOTs found a fail, or an advisory or minor defect, in each area. A test with faults in two areas counts in both.

Toyota Auris at 8 years (n=65,525) against all cars at 8 years (n=10,440,457). Per 100 MOTs.
Area	Fails	All cars	Advisories	All cars
Lights and electrics	9.5	7.3	4.2	3.4
Tyres	5.5	6.3	20.5	25.2
Brakes	4.1	4.8	15.8	19.1
Suspension	3.2	6.1	13.4	11.8
Windscreen, wipers and mirrors	3.1	3.7	2.6	3.4
Exhaust, emissions and leaks	0.7	2.1	0.4	2.3
Steering	0.5	1.2	1.4	1.5
Body and structure	0.3	1.8	0.5	2.2
Number plates and VIN	0.2	0.3	1.1	1.4
Seat belts and airbags	0.2	0.5	0.1	0.3
Road wheels	0.2	0.3	0.2	0.7

What testers fail most on the Auris at 8 years

Fail items on the Toyota Auris at 8 years (n=65,525), per 100 MOTs, with all cars at the same age (n=10,440,457).
Item	Area	Per 100 MOTs	All cars	Typical repair (estimate)
Brake light not working	Lights and electrics	3.0	1.3	£10 to £47 per lamp
Wipers not clearing screen	Windscreen, wipers and mirrors	2.1	1.7	£15 to £30 per blade
Dipped headlight not working	Lights and electrics	2.1	1.2	£18 to £86 per lamp
Tyre tread below 1.6 mm	Tyres	1.7	2.3	£88 to £145 per tyre
Registration plate lamp(s): inoperative in the case of a single lamp or all lamps	Lights and electrics	1.6	0.8	£10 to £47 per lamp
Brake pads under 1.5 mm	Brakes	1.5	2.0	£72 to £174 per axle (rough guide)
Tyre condition: has a cut in excess of the requirements deep enough to reach the ply or cords	Tyres	1.3	1.3	£88 to £145 per tyre
Headlamp: not working on main beam	Lights and electrics	1.1	0.2	£18 to £86 per lamp
Headlamp aim: too low	Lights and electrics	1.1	1.0	£16 to £39 per car (rough guide)
Handbrake too weak	Brakes	0.9	0.5

Early warnings: advisories and minor defects at 8 years

Advisories and minor defects are recorded, but the car still passes. Across all cars, a part with an advisory or minor defect failed at the next MOT 5.5 times in 100 (n=88,666,940 pairs of consecutive MOTs), against 0.3 times in 100 when the same part had none (n=12,936,860,350).

Advisories and minor defects on the Toyota Auris at 8 years (n=65,525), per 100 MOTs, with all cars at the same age (n=10,440,457).
Item	Area	Per 100 MOTs	All cars	If it needs replacing (estimate)
Tread depth: worn close to legal limit/worn on edge	Tyres	11.8	15.7	£88 to £145 per tyre
Tyre condition: slightly damaged/cracking or perishing	Tyres	7.4	8.6	£88 to £145 per tyre
Brake pads: wearing thin	Brakes	6.9	8.6	£72 to £174 per axle (rough guide)
Brake discs: worn, pitted or scored, but not seriously weakened	Brakes	6.9	8.6	£148 to £376 per axle (rough guide)
Suspension arm pins and bushes: pin or bush worn but not resulting in excessive movement	Suspension	5.5	4.0	£92 to £237 per arm (rough guide)
Shock absorbers: has light misting of oil	Suspension	4.1	2.8	£122 to £484 per axle (pair) (rough guide)
Brake discs: worn, but not excessively	Brakes	3.1	2.7	£148 to £376 per axle (rough guide)
Registration plate lamp(s): inoperative in the case of multiple lamps or light sources	Lights and electrics	2.4	1.9
Tread depth: worn close to legal limit/worn on edge	Tyres	1.8	2.1	£88 to £145 per tyre
Child Seat fitted not allowing full inspection of adult belt	Other	1.7	2.3

Repair estimates are a guide for an independent garage: labour at the national median local garage rate (median £78 an hour from 65 garages, ONS price quotes) times estimated labour hours, plus a parts band. Labour hours and most parts bands are estimates, not quotes, and prices vary by model, engine and region. A warning light fault shows the cost of the diagnosis only.

How problems change with age

Fails per 100 MOTs in the three most common areas at 8 years. Ages with fewer than 1,000 tests are not shown.
Age	Tests (n)	Lights and electrics	Tyres	Brakes
3 years	1,282	8.6	4.1	1.1
4 years	15,319	7.6	4.8	1.2
5 years	29,424	8.3	4.9	1.8
6 years	45,424	9.1	5.1	2.6
7 years	62,121	9.4	5.3	3.2
8 years	65,525	9.5	5.5	4.1
9 years	65,094	9.7	5.5	4.5
10 years	57,212	11.1	5.8	5.1
11 years	48,569	13.5	5.5	6.1
12 years	41,625	16.7	5.4	7.3
13 years	39,506	19.9	5.4	9.1
14 years	43,531	20.5	5.3	10.7
15 years	45,434	20.4	5.7	12.0
16 years	33,435	21.3	5.5	12.8
17 years	21,063	22.2	6.2	13.8
18 years	9,386	22.3	5.4	13.2

Mileage

At 8 years, Toyota Auris cars showing under 30,000 miles failed 11.1% of MOTs (n=6,180); the band that failed most, over 150,000 miles, failed 25.5% (n=9,224). For pass and fail rates by age, see Toyota Auris MOT fail rates.

What to check on a viewing

On the Toyota Auris, testers most often record brake light not working; wipers not clearing screen; dipped headlight not working. Look at these first, then the areas below.

Lights and electrics

With someone outside, try every light: dipped and main beam, indicators, brake lights, fog lights and number plate lamps.
Check that the warning lights come on with the ignition and go out once the engine runs.
Look for misted, cracked or yellowed headlamp lenses.

Tyres

Check the tread across the full width of all four tyres, and the spare if there is one.
Look for cuts, bulges and cracking in the sidewalls.
Wear on one edge only can point to worn suspension or the tracking being out.

Brakes

On the test drive the car should stop in a straight line without pulling, juddering or grinding.
Look at the discs through the wheels for a deep lip, heavy rust or scoring.
Check that the handbrake or electronic parking brake holds the car on a slope.
Ask when the pads, discs and brake fluid were last changed, and for the receipts.

Ask for the car's MOT history and service record: advisories that repeat from one year to the next show what has been left. GOV.UK MOT history.

Questions

What are the most common problems on the Toyota Auris?

At 8 years, the age with the most MOT tests (65,525), the fail items testers record most often on the Toyota Auris are brake light not working (3.0 per 100 MOTs), wipers not clearing screen (2.1 per 100 MOTs), dipped headlight not working (2.1 per 100 MOTs). The most common advisories or minor defects are tread depth: worn close to legal limit/worn on edge (11.8) and tyre condition: slightly damaged/cracking or perishing (7.4).

Which parts of the Toyota Auris fail more often than on other cars?

At 8 years: lights and electrics (9.5 per 100 MOTs against 7.3 for all cars). Compared with 10,440,457 MOTs of all cars the same age.

Toyota Auris problems by area

Other Toyota models

All Toyota models · Common problems by make

Read this with care. A fail rate is not a measure of build quality. How far cars are driven, how they are used and how well owners maintain them all change it, and wear items such as tyres and brake pads are common fails. Compare a model only with cars of the same age. Methodology and limits.

The all cars figures cover all class 4 vehicles (cars and light vans) tested at the same age.

Looking at a Toyota Auris?

These figures describe the model, not the car in front of you. Found one you might buy? See what the VetTheCar Buying Report covers, or use the tools that work without a registration.

See a sample report Car tools · MOT fail rates by model · Compare models by MOT record

Repair estimates: ONS consumer price quotes for local garage labour (09/2025 to 08/2026), the MOT inspection manual for defect wording, and estimated labour hours and parts bands. Not affiliated with or endorsed by ONS.

Source

Contains public sector information licensed under the Open Government Licence v3.0. Source: DVSA anonymised MOT test data, class 4 normal MOT tests, 2022 to 2025. MOT data updated 28 September 2026.

Not affiliated with or endorsed by DVSA. How we calculate these figures · Data sources