Common problems

Hyundai Veloster common problems

What MOT testers find on the Hyundai Veloster: the parts that fail or get advisories most often at each age, against all cars of the same age. From 10,010 DVSA MOT tests taken 2022 to 2025.

MOT data updated 28 September 2026

At 10 years, the most tested age

Brakes fails per 100 MOTs (n=2,587)12.4

All cars at 10 years (n=9,049,507)6.5

Brakes advisories and minor defects per 100 MOTs (n=2,587)25.6

All cars, same age (n=9,049,507)21.6

What stands out

Steering fails show up on 9.1 of every 100 MOTs of a Hyundai Veloster at 10 years old (n=2,587), against 2.1 for all cars of that age (n=9,049,507).
Body and structure fails are less common: 0.6 per 100 MOTs against 2.9 for all cars at the same age.
The fail item testers record most often at 10 years: steering track rod end: ball joint play, on 7.8 per 100 MOTs (all cars 1.3).
The most common advisory or minor defect: tread depth: worn close to legal limit/worn on edge, on 14.8 per 100 MOTs.

Problems by part at 10 years

How many of every 100 MOTs found a fail, or an advisory or minor defect, in each area. A test with faults in two areas counts in both.

Hyundai Veloster at 10 years (n=2,587) against all cars at 10 years (n=9,049,507). Per 100 MOTs.
Area	Fails	All cars	Advisories	All cars
Brakes	12.4	6.5	25.6	21.6
Suspension	10.7	9.7	12.9	18.2
Lights and electrics	10.2	11.2	4.8	5.9
Tyres	9.6	6.9	25.2	26.4
Steering	9.1	2.1	6.1	2.4
Windscreen, wipers and mirrors	4.8	4.4	3.6	3.9
Exhaust, emissions and leaks	1.4	2.8	1.1	4.0
Seat belts and airbags	1.4	0.7	0.2	0.4
Body and structure	0.6	2.9	2.4	3.9
Number plates and VIN	0.4	0.3	1.5	2.0
Road wheels	0.3	0.4	1.4	0.8

What testers fail most on the Veloster at 10 years

Fail items on the Hyundai Veloster at 10 years (n=2,587), per 100 MOTs, with all cars at the same age (n=9,049,507).
Item	Area	Per 100 MOTs	All cars	Typical repair (estimate)
Steering track rod end: ball joint play	Steering	7.8	1.3	£54 to £128 per side (rough guide)
Dipped headlight not working	Lights and electrics	4.6	1.7	£18 to £86 per lamp
Handbrake too weak	Brakes	4.4	1.0
Tyre tread below 1.6 mm	Tyres	3.8	2.7	£88 to £145 per tyre
Coil spring broken	Suspension	3.4	3.2	£64 to £236 per spring (rough guide)
Suspension arm ball joint dust cover: ball joint dust cover no longer prevents the ingress of dirt	Suspension	3.1	0.5	£75 to £237 per side (rough guide)
Parking brake performance: inoperative on one side	Brakes	2.6	0.5
Brake pads under 1.5 mm	Brakes	2.2	2.1	£72 to £174 per axle (rough guide)
Washers: provides insufficient washer liquid	Windscreen, wipers and mirrors	2.1	1.5	£2 to £14 per car (rough guide)
Tyre pressure monitoring system: malfunctioning or obviously inoperative	Tyres	2.0	0.7	£53 to £125 per wheel (rough guide)

Early warnings: advisories and minor defects at 10 years

Advisories and minor defects are recorded, but the car still passes. Across all cars, a part with an advisory or minor defect failed at the next MOT 5.5 times in 100 (n=88,666,940 pairs of consecutive MOTs), against 0.3 times in 100 when the same part had none (n=12,936,860,350).

Advisories and minor defects on the Hyundai Veloster at 10 years (n=2,587), per 100 MOTs, with all cars at the same age (n=9,049,507).
Item	Area	Per 100 MOTs	All cars	If it needs replacing (estimate)
Tread depth: worn close to legal limit/worn on edge	Tyres	14.8	17.0	£88 to £145 per tyre
Brake discs: worn, pitted or scored, but not seriously weakened	Brakes	9.5	9.6	£148 to £376 per axle (rough guide)
Brake pads: wearing thin	Brakes	9.2	8.1	£72 to £174 per axle (rough guide)
Rigid brake pipes: corroded, covered in grease or other material	Brakes	7.0	2.8	£137 to £392 per car (rough guide)
Tyre condition: slightly damaged/cracking or perishing	Tyres	6.9	8.6	£88 to £145 per tyre
Track rod end: ball joint has slight play	Steering	5.5	1.1	£54 to £128 per side (rough guide)
Registration plate lamp(s): inoperative in the case of multiple lamps or light sources	Lights and electrics	3.6	3.2
Suspension arm ball joint dust cover: ball joint dust cover severely deteriorated	Suspension	3.1	0.7
Tyre condition: has a cut but not deep enough to reach the ply or cords	Tyres	2.7	1.3	£88 to £145 per tyre
Nail in tyre	Other	2.2	1.9

Repair estimates are a guide for an independent garage: labour at the national median local garage rate (median £78 an hour from 65 garages, ONS price quotes) times estimated labour hours, plus a parts band. Labour hours and most parts bands are estimates, not quotes, and prices vary by model, engine and region. A warning light fault shows the cost of the diagnosis only.

How problems change with age

Fails per 100 MOTs in the three most common areas at 10 years. Ages with fewer than 1,000 tests are not shown.
Age	Tests (n)	Brakes	Suspension	Lights and electrics
9 years	1,059	10.1	8.5	7.1
10 years	2,587	12.4	10.7	10.2
11 years	2,554	13.4	10.5	9.9
12 years	2,348	14.9	12.9	11.2
13 years	1,462	14.8	12.7	10.8

What to check on a viewing

On the Hyundai Veloster, testers most often record steering track rod end: ball joint play; dipped headlight not working; handbrake too weak. Look at these first, then the areas below.

Brakes

On the test drive the car should stop in a straight line without pulling, juddering or grinding.
Look at the discs through the wheels for a deep lip, heavy rust or scoring.
Check that the handbrake or electronic parking brake holds the car on a slope.
Ask when the pads, discs and brake fluid were last changed, and for the receipts.

Suspension

Listen for knocks or clonks over speed bumps and rough roads on the test drive.
Push down hard on each corner: the car should settle at once rather than keep bouncing.
Look behind the wheels for broken or heavily rusted coil springs and split rubber bushes.
Check that the car sits level and that no tyre is worn on one edge only.

Lights and electrics

With someone outside, try every light: dipped and main beam, indicators, brake lights, fog lights and number plate lamps.
Check that the warning lights come on with the ignition and go out once the engine runs.
Look for misted, cracked or yellowed headlamp lenses.

Ask for the car's MOT history and service record: advisories that repeat from one year to the next show what has been left. GOV.UK MOT history.

Questions

What are the most common problems on the Hyundai Veloster?

At 10 years, the age with the most MOT tests (2,587), the fail items testers record most often on the Hyundai Veloster are steering track rod end: ball joint play (7.8 per 100 MOTs), dipped headlight not working (4.6 per 100 MOTs), handbrake too weak (4.4 per 100 MOTs). The most common advisories or minor defects are tread depth: worn close to legal limit/worn on edge (14.8) and brake discs: worn, pitted or scored, but not seriously weakened (9.5).

Which parts of the Hyundai Veloster fail more often than on other cars?

At 10 years: steering (9.1 per 100 MOTs against 2.1 for all cars); brakes (12.4 per 100 MOTs against 6.5 for all cars); tyres (9.6 per 100 MOTs against 6.9 for all cars). Compared with 9,049,507 MOTs of all cars the same age.

Hyundai Veloster problems by area

Other Hyundai models

All Hyundai models · Common problems by make

Read this with care. A fail rate is not a measure of build quality. How far cars are driven, how they are used and how well owners maintain them all change it, and wear items such as tyres and brake pads are common fails. Compare a model only with cars of the same age. Methodology and limits.

The all cars figures cover all class 4 vehicles (cars and light vans) tested at the same age.

Looking at a Hyundai Veloster?

These figures describe the model, not the car in front of you. Found one you might buy? See what the VetTheCar Buying Report covers, or use the tools that work without a registration.

See a sample report Car tools · MOT fail rates by model · Compare models by MOT record

Repair estimates: ONS consumer price quotes for local garage labour (09/2025 to 08/2026), the MOT inspection manual for defect wording, and estimated labour hours and parts bands. Not affiliated with or endorsed by ONS.

Source

Contains public sector information licensed under the Open Government Licence v3.0. Source: DVSA anonymised MOT test data, class 4 normal MOT tests, 2022 to 2025. MOT data updated 28 September 2026.

Not affiliated with or endorsed by DVSA. How we calculate these figures · Data sources